Need Help?

1992 Isuzu Rodeo LS 4dr Wagon 5-Spd

1992 Isuzu Rodeo
Do you own this car?
Estimated Mileage
 Miles
Enter current mileage for most
accurate info about this vehicle


Track Your Service Records
Get Recall Alerts
Get Updated Value Estimates on Your Car.

back to question list

Ask the Community

Ask Our Auto Mechanics


October 29, 2012, 4:43 pm

Brandon H
 

Question: how do i replace the thermostat on my 1999 isuzu rodeo LS v6 3.2 L 2wheel drive vehicle

its over heating only in town fine on highway took it to mechanic didnt act up got air out of radiator was fine for awhile actin up again sick of it going to try replacing thermostat


November 10, 2012, 7:39 am

Tyler O
Expert Mechanic

REMOVAL

Disconnect battery ground cable.
Drain engine coolant from the radiator and engine.
Disconnect radiator hose from the inlet pipe.
Remove thermostat housing.
Remove thermostat (2).

INSPECTION
Suspend the thermostat in a water-filled container using thin wire. Place a thermometer next to the thermostat. Do not directly heat the thermostat.




Gradually increase the water temperature. Stir the water cm that the entire water is same temperature.
Confirm the temperature when the valve first begins to open.

Valve opening temperature 74.5°C - 78.5°C (166.1°F - 173.3°F)

Confirm the temperature when the valve is fully opened.

Valve full open temperature and lift More than 8.5mm (0.33 inch) at 90°C - (194°F)

Make necessary repair and parts replacement if extreme wear or damage is found during inspection.

INSTALLATION

Install thermostat into the outlet pipe(4) making sure that the air hole is in the up position.
Install thermostat housing and tighten bolts to the specified torque.

Torque: 25 Nm (18 ft. lbs.)

Installation rubber hose.
Replenish Engine Coolant (EC).
Start engine and check for EC leakage.


0/0 users found this helpful.

Ask our panel of certified auto mechanics a question. We pay for their advice so you don't have to



My Auto Score

See the free AutoCheck score

Meet The Experts
Kim Perrin
Kim Perrin is our resident mechanic here at DriverSide. Kim worked as…
Tyler Orr
Tyler Orr is an expert in German and Japanese cars and has been a mechanic …
Elizabeth Kriesten
Elizabeth Kriesten worked as an automotive technician for several years at Dodge…
Tips on Servicing

Car Brakes: How Do You Know When to Change Them?

By Zach Bowman For those who suffer a daily commute through heavy traffic, your vehicle's braking system can bring thousands of pounds of metal, plastic and empty Starbucks cups to a stop hundreds of times before you get to work. It goes without saying that these pieces wear out, but they do so slowly, meaning you may not notice they need attention until ...

Read more…